Flexio 2000 Sprayer

$ 129.99
The FLEXiO 2000 hand-held sprayer, has 2 speeds and can paint a wall 8 times faster than a brush, saving time and effort on big surface projects like walls, exterior siding, and fences.

The new nozzle design delivers an improved spray pattern and adjustable control with less mess and overspray.

It has the flexibility to spray indoors and out with the power to spray unthinned paint and stains with full coverage. Cleaning is faster than a brush or roller with just a few removable parts that separate and rinse clean.

Covers an 8’x10’ surface in minutes:
-Stain: 2 minutes
-Latex: 6 minutes


FLEXiO 2000 - Launch
FLEXiO 2000 - Launch Video
FLEXiO Sprayers - SetUp
FLEXiO Sprayers - SetUp Video


  • X-Boost® Power Dial - 2 settings for thin and thick materials
  • iSpray® Nozzle - For walls and siding
  • 1 ½ quart cup covers up to a 10’ by 12’ wall in one fill
  • Precise adjustments for various coatings and projects
  • Lock-n-Go® split gun design for quick cleaning
  • Cleans up in 5 minutes - just five parts to rinse off
Download Manual
Flexio 2000 is rated 4.9 out of 5 by 14.
Rated 5 out of 5 by from Good made better I owned an older Wagner airless painter for years and decided to upgrade to the Flexio2000. Awesome choice! Super easy to use and super easy to clean. I painted the wood part of my shed in about an hour a task that would have taken several hours with a brush.
Date published: 2018-01-09
Rated 5 out of 5 by from Wagner Makes it Easy I used the Wagner Flexio 2000 for the first time to spray my livingroom walls, worked excellent right out of the box. First off, Wagner gives you excellent directions and a "spray poster" to teach you how to apply with the sprayer. I used a flat enamel with primer in it, it was very thick so I decided to thin it just a little with water, I didn't want to clog the tip. After reading up on the the settings to use, I was off and running! One 12' wall took about a half hour, way faster than rolling! I had some floor molding and window trim that I didn't even have to tape off the spray pattern was precise. Clean up couldn't be easier. Everything comes apart so you can clean it well. Very impressed with the Flexio, makes me want to paint every room now! Wagner makes it so easy.
Date published: 2017-11-05
Rated 5 out of 5 by from Easy to use with quick and easy clean up Sprayer was easy to set up and worked as described. I used to spray stain which is fairly thick on a pole barn and the sprayer worked flawlessly. I was able to apply the stain evenly and quickly which made the project easier to complete. Completely satisfied.
Date published: 2017-11-05
Rated 5 out of 5 by from Super Easy Have all you pieces prepped and staged to keep the sprayer moving across the surfaces. I find as long as you do this you won't have clogging.
Date published: 2017-11-03
Rated 5 out of 5 by from Easy to Use For a Beginner I used the FLEXIO 2000 to repaint a ceiling that had water damage from a leaking roof. This was the first time that I used a paint sprayer for any type of interior painting. The directions that came with the unit were easy to understand. In particular the chart at the bottom of page 8 was very helpful, as well as the masking guide. As suggested, I first sprayed water to get a feel for how the sprayer worked. It only took a few passes with paint before before I was comfortable with spraying. I started with the Flow level at the recommended rate of 9, and adjusted to 10 which gave the coverage that I wanted. Once I got going I was able to keep over spray to a minimum. For me the Round Pattern for spray worked best. Other than that I found the sprayer a little heavy for spraying a ceiling, the sprayer work well. Cleanup is straight forward and relatively pain free. Again the instruction guide for cleanup is very user friendly.
Date published: 2017-11-03
Rated 5 out of 5 by from Excellent painting This product gives a nice even coat of paint. It's so easy to use, would be great for customers in a hurry. Don't have to assemble any little pieces either. Over all a great product.
Date published: 2017-11-03
Rated 4 out of 5 by from If used properly, a real time saver! I received this product a little less than a month ago and overall I am pretty impressed. Bottom line upfront: follow the instructions if you want to have a successful experience. For starters, the item is packaged well and the instructions are very easy to understand a follow. A spray pattern guide, over-spray map, and clear instructions are included to get you started with the HVLP sprayer. The product was set up within minutes and I was ready to execute my first task; spraying water based polyurethane on my workbench. The instructions recommended a medium spray setting with high power to properly spread the poly. I sprayed the poly un-thinned and the coverage was very even. As with many topcoats, the first coat was a bit rough but evened out well with the second coat. I went on to spray some latex paint, however for this I decided to thin the paint some. My method was to fill the sprayer tank to the same level for each refill and thin with a set amount of product to maintain an even coat (I used a quarter prescription bottle of thinner to each 30oz of paint). About the product and pros: You will probably think it feels out of balance if you pick it up at a store or initially out of the box. This is quickly remedied when you fill the tank as it holds up to 45oz of paint. The build feels very sturdy and long-lasting. The sprayer is very powerful so following the recommendations for different paints/top coats is a must. You should have no issue spraying un-thinned paints through the Flexio 2000. The motor is relatively quiet and I was able to use it while a small child was napping upstairs without incident. Finally, clean up was a breeze. I filled the tank with water and sprayed it through then rinsed 3 parts and I was done for the day. It could not have taken more than 5 minutes to have the item broken down, cleaned, and set up to dry. A few improvements I would like to see: Inclusion of a filter with flexible feed tube - The feed tube is hard plastic and does not include a filter. Any misses when mixing your paint or dried chips will surely be plastered to your finished product so mix carefully before use. Also, once you're low on paint you will have an air sprayer if attempting to spray anything above line of sight so refill often. The feed tube is the reason for four stars instead of five alone. The initial spray left me with some runs that I had to spread with a paintbrush. The instructions will tell you to start the spray (with just the turbine) with an offset from your desired target. My recommendation is to start on a piece of scrap or open air if your're outside then run the even flow onto your product. I included a picture of the initial spray run. Reduced over-spray - If using indoors, you will need to mask a substantial amount of real estate to protect from over-spray. This might be nature of the beast with HVLP sprayers but you will need to judge your space and whether masking everything will cost more time than painting by hand. Overall, this product saved me a ton of time with my workbench compared to what I would have done with a brush in hand around all the surfaces. The over-spray didn't reach anything else in my work area so time spent masking was a non-issue. Bottom line: follow the instructions. I am willing to bet that many of the negative reviews are a direct result of operator error.
Date published: 2017-11-03
Rated 5 out of 5 by from easy to use I got the FLEXIO 2000 about a week ago did a test spray with water first and was pleased with how powerful the spray was and how comfortable the sprayer felt in my hand, it didn't feel like I was holding alot of weight. I had a wooden shed that was in need of repainting, so after pressure washing it and letting it dry I used the Flexio 2000 to repaint it using this sprayer I was able to paint the entire shed in about 20 minutes and it covered so well I only had to use 1 coat of paint. After that dried I switched the painting tip so I could repaint the trim work on the shed, this sprayer was very easy to control and made it very easy to do the trim with very little overspray. Cleaning the sprayer was just about as easy as painting with it.
Date published: 2017-11-02
  • y_2018, m_3, d_18, h_23
  • bvseo_bulk, prod_bvrr, vn_bulk_2.0.7
  • cp_1, bvpage1
  • co_hasreviews, tv_0, tr_14
  • loc_en_US, sid_024964272136, prod, sort_[SortEntry(order=SUBMISSION_TIME, direction=DESCENDING)]
  • clientName_wagnerspraytech
  • bvseo_sdk, p_sdk, 3.2.0
  • CLOUD, getContent, 63.99ms

Is the FLEXIO 2000 ideal for spraying a wood fence with Thompson's WaterSeal Transparent Waterproofing Stain (Woodland cedar)?

Asked by: Alabama Rich
It is ideal for that project.
Answered by: Wagner
Date published: 2018-03-07

What is the main difference between the 2000 and 3000 model. I am going to stain a deck and will either one work on the horizontal deck surface.

Asked by: Damoco
The Flexio 2000 and the Flexio 3000 come with the iSpray front end for spraying general purpose projects like staining the deck or painting the fence. The 3000 also comes with the detail front end for painting your trim or shelving or cabinets. For more info call us at 800-328-8251.
Answered by: Wagner
Date published: 2018-02-14

Using latex paint sometimes my sprayer sprays out unevenly and messy, just like splatters paint out...how do I fix this?

Asked by: tJaker
The Flexio 2000 with the iSpray front end is designed to spray unthinned latex paint on large projects, like the deck, fence or side of the house. It will spray a lot of paint and sometimes requires limitations. Latex paint is thick, so keep the power up high, but reduce the amount of paint flow. This should reduce the spit and the overall pattern size, resulting in a more controlled paint distribution. You should be spraying from no farther than about 10", but at 6" you'll have more control. If you have more questions call us at 800-328-8251.
Answered by: Wagner
Date published: 2018-02-07

Hi, just purchased this. Are you able to use concrete paint with this? How about Drylock?

Asked by: WDBTD
The Flexio line of HVLP can spray most household latex paints. Thicker materials will require some thinning. Something like Drylok cannot be sprayed using HVLP, it's best rolled using a 3/4" nap roller. For more tips call us at 800-328-8251.
Answered by: Wagner
Date published: 2018-01-23

Can this be used tilted/inverted to spray ceilings? I read on another site it might damage this model. Is that true?

Asked by: danb
The Flexio 570, 590, 2000, and 3000 cannot be tilted upward at more than a 45 degree angle or paint could run back into the motor. If you would like to discuss what product would be best for your project feel free to call us at 1-800-328-8251.
Answered by: Wagner
Date published: 2017-12-29

Can this be used to spray lacquer or polyurethane on cabinets?

Asked by: mikke
Only water based or oil based finishes can be sprayed with Wagner sprayers. We have other systems for furniture finishing with lacquer. Give us a call at 800-328-8251.
Answered by: Wagner
Date published: 2017-12-11
  • y_2018, m_3, d_18, h_23CST
  • bvseo_bulk, prod_bvqa, vn_bulk_2.0.7
  • cp_1, bvpage1
  • co_hasquestionsanswers, tq_6
  • loc_en_US, sid_024964272136, prod, sort_[SortEntry(order=LAST_APPROVED_ANSWER_SUBMISSION_TIME, direction=DESCENDING)]
  • clientName_wagnerspraytech
  • bvseo_sdk, p_sdk, 3.2.0
  • CLOUD, getContent, 64.21ms
Stay Connected

Find out what’s new from Wagner including product news, exclusive email offers, promotions and more.